Product ID:OATEY LO-VOC PURPLE PRIMER NSF, 31894
MSDS Date:01/01/1996
FSC:8040
NIIN:00N083515
MSDS Number: CGQWP

OATEY

4700 WEST 160TH ST
CLEVELAND, OH 44135
US

Emergency Phone: 303-623-5716;800-424-9300(CHEMTREC)

Info Phone: 216-267-7100

Cage: IO629

OATEY CO

35906 CLEVELAND, OH 44135 US

Telephone: 216-267-7100/303-623-5716

Cage: 53472

2-BUTANONE; (METHYL ETHYL KETONE) (SARA 313) (CERCLA)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 70-80%

OSHA PEL 200 PPM

ACGIH TLV: 200 PPM; 300 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

CYCLOHEXANONE (CERCLA)

CAS: 108-94-1

RTECS: GW1050000

Fraction By Weight: 12-16%

OSHA PEL 50 PPM, S

ACGIH TLV: 25 PPM, S

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

FURAN, TETRAHYDRO-; (TETRAHYDROFURAN) (CERCLA)

CAS: 109-99-9

RTECS: LU5950000

Fraction By Weight: 10-15%

OSHA PEL 200 PPM

ACGIH TLV: 200 PPM; 250 STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ACETONE (SARA 313) (CERCLA)

CAS: 67-64-1

RTECS: AL3150000

Fraction By Weight: 1-5%

OSHA PEL 1000 PPM

ACGIH TLV: 750 PPM; 1000 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ANTHRAQUINONE, 1-HYDROXY-4-(P-TOLUIDINO)-; (VIOLET DYE)

CAS: 81-48-1

RTECS: CB7700000

Fraction By Weight: <1%

OSHA PEL N/K

ACGIH TLV: N/K

C.I. SOLVENT RED 26; (RED DYE)

CAS: 4477-79-6

Fraction By Weight: <1%

OSHA PEL N/K

ACGIH TLV: N/K

70-80% WT

RTECS: 9999999VO

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHAL: MAY CAUSE IRRITATION OF MUCOUS
MEMBRANES, NOSE AND THROAT, HEADACHE, DIZZINESS, NAUSEA, NUMBNESS
OF EXTREMITIES AND NARCOSIS IN HIGH CONCS. HAS CAUSED CNS DEPRESS
AND LIVER DAMAGE IN ANIMALS AN D CONCENTRATIONS OF 1000-3000 PPM
CAUSERETARDATION OF FETAL DEVELOPMENT IN RATS. EYE: VAPOR OR DIRECT
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: CONTACT MAY CAUSE IRRITATION. INGEST:
MAY BE ASPIRATED INTO LUNGS OR CAUSE SYSTEMIC EFFECTS DESCRIBED
UNDER INHAL. SKIN: CHRONIC CONTACT MAY LEAD TO IRRITATION AND
DERMATITIS. CHRONIC EXPOSU RE TO VAPORS OF HIGH CONC MAY CAUSE
DERMATITIS. MAY POSSIBLY BE ABSORBED THRU SKIN. TARGET ORGANS: EYE,
SKIN, LUNG, CNS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:SKIN: FLUSH W/WATER THEN WASH THOROUGHLY W/SOAP AND WATER.
REMOVE CONTAMINATED CLOTHING AND WASH BEFORE REUSE. CALL POISON
CONTROL CENTER OR MD IF IRRITATION PERSISTS. EYES: FLUSH W/WATER
FOR AT LEAST 15 MINUTES AND CALL POISON CONTROL CENTER OR MD IF
IRRITATION PERSISTS. INHAL: MOVE TO FRESH AIR. IF BREATHING IS
DIFFICULT, GIVE OXYGEN. IF NOT BREATHING, GIVE ARTIFICIAL
RESPIRATION. KEEP (SUPDAT)

Flash Point Method:PMCC
Flash Point:>0F,>-18C
Lower Limits:1.8%
Upper Limits:11.8%
Extinguishing Media:FOR SMALL FIRES: USE DRY CHEMICAL, CARBON DIOXIDE,
WATER OR FOAM EXTINGUISHER.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . FOR LARGE FIRES, EVACUATE AREA AND CALL FIRE DEPARTMENT
IMMEDIATELY.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.

Spill Release Procedures:VENTILATE AREA, STOP LEAK IF IT CAN BE DONE
WITHOUT RISK. TAKE UP WITH SAND, EARTH OR OTHER NON-COMBUSTIBLE
ABSORBING MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS AND
FLAMES; STORE IN COOL, DRY PLACE.
Other Precautions:CONTAINERS, EVEN EMPTIES WILL RETAIN RESIDUE AND
VAPORS.

Respiratory Protection:NIOSH APPROVED CANNISTER RESPIRATOR IN ABSENCE
OF ADEQUATE VENTILATION.
Ventilation:GENERAL MECHANICAL: EXHAUST VENT CAPABLE OF MAINTAINING
EMISSIONS AT POINT OF USE BELOW PEL. LOCAL EXHAUST: (SUPDAT)
Protective Gloves:RUBBER GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC: VICTIM QUIET & WARM. CAL POIS CONTROL CENTER OR MD
IMMED. INGEST: DRINK WATER & CAL POISON CONTROL CENTER OR MD IMMED.
AVOID ALCOHOLIC BEVERAGES. NEVER GIVE ANYTHING BY MOUTH TO AN UNC
ON PERSON. DO NOT INDUCE VOMITING. VENT: OPEN DOORS AND WINDOWS. IF
USED IN ENCLOSED AREA, USE EXHAUST FANS.

Boiling Pt:B.P. Text:151F,66C
Vapor Pres:145 @ 20C
Vapor Density:2.5
Spec Gravity:0.94 0.01
Evaporation Rate & Reference:5.5-8.0 (BUAC=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR LIQUID; ETHER-LIKE ODOR.

Stability Indicator/Materials to Avoid:YES
ACIDS, OXIDIZING MATLS, ALKALIS, CHLORINATED INORGS (POTASSIUM, CALCIUM
& SODIUM HYPOCHLORITE), COPPER OR COPPER ALLOYS.
Stability Condition to Avoid:HEAT, SPARKS AND OPEN FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE/CARBON
DIOXIDE/HYDROGEN CHLORIDE/SMOKE.

Waste Disposal Methods:DISPOSE OF ACCORDING TO LOCAL, STATE AND FEDERAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.